BF flotation cell has two types: type I and type II. Type I is improved as suction cell referring to model SF; type II is improved as direct flow cell referring to model JJF.
Each feeding inlet of Xinhai cyclone unit is installed knife gate valve independently developed by Xinhai. This valve with small dimension reduces the diameter of cyclone unit.
The supports at both ends of cone crusher main shaft, scientific design of crushing chamber, double insurance control of hydraulic and lubricating system.
Wet type overflow ball mill is lined with Xinhai wear-resistant rubber sheet with excellent wear resistance, long service life and convenient maintenance
Wet type grid ball mill is lined with Xinhai wear-resistant rubber sheet with excellent wear resistance design, long service life and convenient maintenance.
Ring groove rivets connection, plate type screen box, advanced structure, strong and durable Vibration exciter with eccentric shaft and eccentric block, high screening efficiency, large capacity
Xinhai improves the traditional specification of crushing chamber by adopting high speed swing jaw and cambered jaw plate.
High-speed hammer impacts materials to crush materials. There are two ways of crushing (Wet and dry)
The cone slide valve is adopted; the failure rate is reduced by 80%; low energy consumption;the separation of different material, improvement of the processing capacity by more than 35%.
Cylindrical energy saving grid ball mill is lined grooved ring plate which increases the contact surface of ball and ore and strengthens the grinding.
20-30%. Rolling bearings replace slipping bearings to reduce friction; easy to start; energy saving 20-30%
Both sides of the impeller with back rake blades ensures double circulating of slurry inside the flotation tank. Forward type tank, small dead end, fast foam movement
Figure 1 Schematic diagram of a mechanical flotation cell. 1,. Discharge box; 2 . or both, depending on the capacity of launder neces- sary for froth removal.
The Xinhai Minerals DR Flotation Machine is the first is minimised, as the pulp is 100% mixed in every cell as it DR – Cell volumes & hydraulic capacities.
During the 1990s, Jameson Cells had great success in coal fines flotation and Figure 2: Comparison of column and Jameson Cell sizes of similar capacity. .. The Jameson Cell rougher tailings would feed the 4x100m3 At 1000tph.
Bacís flotation cell for gold- And silver-beard pyrite recovery to mechanical flotation cells: column height, cost of compressed air supply and low capacity and the largest plants in the world have installed 100 m 3 3,500 cu ft and recently as
The RCS flotation machine combines the benefits of circular cells with the unique features of the DV The new improved RCS flotation cell is an all purpose flotation machine suitable for all flotation 50%, 75%, 100%, 125%, 150%, 175%, 200%, 300%, 400% Plant capacity 25.000 tpd with 0,35% Cu in the feed.
Large flotation cells up to 660 m³ capacity. FLSmidth now supplies the 300-660m3 SuperCell™ flotation cell which is the largest operating flotation cell in the
Separate flotation of this feed using mechanical cells could recover only about 60% of the phosphate. There are two potential applications for even finer minus 100 mesh flotation in 137. 180. 1 Assuming 1000 tph feed, floated at 25% solids. If the limiting carrying capacity of the froth had been reached, lower.
1993-2018 Xinhai Machine . All rights reserved | Design by Xinhai